Matters needing attention in the operation of diesel

Author：gdlhwt Time：2014-09-15  

Diesel generator needs to be checked in the load operation, after passing the examination in order to start running, of course, this and the usual maintenance and correct operation cannot do without.

1, oil level in the specified scale line, the oil pressure of not less than 0.2MPA after the start of.

2, the engine air filter pollution warning signs should be green, if the replacement of a new air filter shows red in operation before the load.

3, set machine has reliable effective grounding, cable is properly connected and reliable non Popi phenomenon.

4, diesel generators and air switch on-off freely flexible, air switch capacity should be close to the magnitude of the current and the effective protection.

5, in the radiator coolant should be in the saturated state, the temperature of the cooling liquid can take full load running in 60 Celsius above (power 80%), running load should be small load slowly increase the rules of operation.

In 6, after a successful start-up no-load voltage 400V, frequency 50HZ, three-phase voltage balancing without large deviation. The frequency of less than 47HZ-52HZ to deal with the engine speed check can be load operation.

At the end of 7, the most simple and also very important link, set the diesel tank have enough diesel fuel load generator constant time operation.

Do the above seven items of preparation can be assured that the load operation of diesel generator, good operation habit helps to improve the performance of power generation equipment.